MODERNIZATION OF GAS BOILERS OF TPP, CHP AND BOILERS ROOMS TO THE EU DIRECTIVE ECOLOGICAL REQUIREMENTS

Keywords: nitrogen oxides, combustion, resource, boilers, recirculation

Abstract

The installed capacity of boiler units in Ukraine significantly exceeds the needs for consumers was shown. The remarking of boiler units to lower capacity is the one of the least capital-intensive ways to increase their technical, economic, environmental indicators and the extension of their resource. To achieve EU norms it is necessary to reduce emissions of NOx by 50–80 % for boilers of LCP with an capacity a rated thermal input of 50 MW or more, which operate on natural gas has been established. An increase the concentration of recirculation gases in blow air of more than 25 % of all exhaust gases significantly reduces the concentration of oxygen in the mixture of air and exhaust gases. It’s can cause to: deterioration of combustion, the removal of a torch into the convective part, a significant increase electricity consumption and increase the temperature of the exhaust gases. The using of CO2 or N2 gases for balancing natural gas to reduce NOx emissions is economically impractical. The using of ballasting technology, which based on mixing exhaust gases with natural gas, requires special burners, due to the range of burner power control must be limited. To reduce NOx is advisable to combine several measures simultaneously. The plan an action to implement EU environmental directives by existing boiler units operating on natural gas with an increase their technical and economic indicators has been developed. There is one of the possible ways to implement the EU ecological directives by boiler units in Ukraine, it’s transferring the load from existing LCP with a rated thermal input of 50 MW or more to less powerful ones. For remove combustion plants from the requirements of the EU Directive 2010/75/EU, it is necessary to remark part of the boilers for a new nominal capacity for the purpose of obtaining combustion plants a rated thermal input of less than 50 MW. Bibl. 18, Fig. 6, Tab. 1.

Downloads

Download data is not yet available.

Author Biographies

I.Ya. Sigal, The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv

Doctor of Technical Sciences, Professor

A.V. Smikhula, The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv

Candidate of Technical Sciences

O.V. Marasin, The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv

Candidate of Technical Sciences

E.P. Dombrowska, The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv

Candidate of Technical Sciences

References

Directive 2001/80/EC of the European parliament and of the council of 23 October 2001 on the limitation of emissions of certain pollutants into the air from large combustion plants, 21 p. — http://eur-lex.europa.eu/legal-content/EN/ TXT/?uri=CELEX:32001L0080

Directive 2010/75/EU of the European parliament and of the council of 24 November 2010 on industrial emissions (integrated pollution prevention and control), 119 p. — http://eur-lex. europa.eu/legal-content/EN/TXT/?uri=CELEX: 32010L0075

Enerhetychna stratehiia Ukrainy na period do 2035 roku «Bezpeka, enerhoefektyvnist, konkurentospromozhnist » : Cabinet of Ministers of Ukraine — Law of Ukraine, 18.08.2017 No. 605-р., 66 p. — http:// 195.78.68.67/ minugol/doccatalog/document?id= 245234103 (Ukr.)

Energy Roadmap 2050 / Communication from the commission to the European parliament, the council, the European economic and social committee and the committee of the regions, Brussels, 15.12.2011, 20 p. — http://eur-lex.europa.eu/legal-content/EN/ALL/ ?uri=CELEX:52011DC0885

Sigal I.Ya. Protection of ambient air at fuel burning, Leningrad : Nedra, 1988, 313 p. (Rus.)

DSP 201-97. Derzhavni sanitarni pravyla okhorony atmosfernoho povitria naselenykh mists (vid zabrudnennia khimichnymy ta biolohichnymy rechovynamy) : Nakaz MOZ – Law of Ukraine, 09.07.97 No. 201. — http://mozdocs.kiev.ua/view. php?id =803 (Ukr.)

Sigal I.Ya., Duboshiy A.N., Sigal O.I., Smikhula A.V. The efficiency increase of smoked gases recirculation influence on nitrogen oxides emission from power plant boilers reduction, Energotechnologii i resursosberezhenie [Energy Technologies and Resource Saving], 2010, (1), pp. 48–52. (Rus.) 8. Directive (EU) 2015/2193 of the European parliament and of the council of 25 November 2015 on the limitation of emissions of certain pollutants into the air from medium combustion plants, 19 p. — http://mpe.kmu.gov.ua/minugol/doccatalog/ document?id=244996332

Natsionalnyy plan skorochennya vykydiv vid velykykh spalyuvalnykh ustanovok : Kintsevyy Proekt, Kyiv, 15 mart 2015, 78 p. — http:// eur-lex.europa.eu/legal-content/EN/TXT/?uri= CELEX %3A32015L2193 (Ukr.)

Sigal I.Ya., Smikhula A.V., Duboshiy O.M., Horbunov O.V., Horbunov А.O. Reducing the formation of nitrogen oxides during the combustion of natural gas, Energotechnologii i resursosberezhenie [Energy Technologies and Resource Saving], 2016, (4 ), pp. 44–51. (Rus.)

Taimarov M.A., Chykliaev D.E., Akhmetova R.V., Chykliaev E.H. Vlyianye konstruktyvnykh osobennostei topok kotlov na obrazovanye okyslov azota, Tekhnycheskye nauky v myre ot teoryy k praktyke : Sbornik nauchnykh trudov po ytoham mezhdunarodnoi nauchno-praktycheskoi konferentsyy, Rostov-on-Don, 2014, (5), p. 15–20. (Rus.)

HKD 34.25.509-2003. Peremarkuvannia osnovnoho enerhetychnoho ustatkuvannia enerhopidpryiemstv Ministerstva palyva ta enerhetyky Ukrainy. Polozhennia, Kiev : Obiednannia enerhetychnykh pidpryiemstv «Haluzevyi rezervno-investytsiinyi fond rozvytku enerhetyky», 2003, 29 p. (Ukr.)

Sigal I.Ya., Nizhnik S.S. Zmenshennya utvorennya oksidiv azotu retsirkulyatsieyu produktiv zgoryannya, Tsukor Ukraini, 1994, (3), pp. 14–16. (Rus.)

Sigal I.Ya., Smikhula A.V., Marasin O.V., Lavrentsov E.M. [The increasing duration of operation of boiler houses and heat electro power stations above 12 MW in Ukraine], Energotechnologii i resursosberezhenie resursosberezhenie [Energy Technologies and Resource Saving], 2015, (3), pp. 46–53. (Rus.)

Sigal I.Ya., Smikhula A.V., Lavrentsov E.M., Marasin O.V. Shyrokomasshtabnaia rekonstruktsyia sushchestvuiushchykh kotlov s tseliu umenshenyia raskhoda pryrodnoho haza, Enerhoefektyvnist-2013, Kiev : The Gas Institute of NAS of Ukraine, 2013, pp. 17–20. (Rus.)

Lavrentsov E.M., Sigal I.Ya, Smikhula A.V., Berezanskiy V.V., Ovchar V.V. [Water Boilers of TVG and KVG Types Modernization], Energotechnologii i resursosberezhenie, 2010, (6), pp. 70–76. (Rus.)

Lavrentsov E.M., Sigal I.Ya., Smikhula A.V., Sigal A.I., Kuchin G.P, Skripko V.Ya., Bykorez E.I. [Reconstruction and Modernization of Water-Heating and Steam Boilers in Heat-Systems], Energotechnologii i resursosberezhenie resursosberezhenie [Energy Technologies and Resource Saving], 2012, (3), pp. 63–71. (Rus.)

Sigal I.Ya., Kosinov O.I., Duboshiy O.M., Nizhnik S.S. Povysheniye effektivnosti metodov snizheniya obrazovaniya oksidov azota v topkakh kotlov, Teploenergetika, 1986, (7), pp. 6–9. (Rus.)

Published
2017-12-20
How to Cite
Sigal, I., Smikhula, A., Marasin, O., Lavrentsov, E., & Dombrowska, E. (2017). MODERNIZATION OF GAS BOILERS OF TPP, CHP AND BOILERS ROOMS TO THE EU DIRECTIVE ECOLOGICAL REQUIREMENTS. Energy Technologies & Resource Saving, (4), 61-71. https://doi.org/10.33070/etars.4.2017.09
Section
Environment protection

Most read articles by the same author(s)

1 2 > >>