EXPERIENCE OF DEVELOPMENT, IMPLEMENTATION AND MODERNIZATION OF HOT WATER SUPPLY BOILERS WITH DUAL-SCREENS AND THE SLOT BOTTOM BURNERS

  • E.M. Lavrentsov The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv
  • I.Ya. Sigal The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv
  • A.V. Smikhula The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv
  • E.P. Dombrowska The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv
  • O.S. Kernazhytska The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv
  • O.V. Marasin The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv
Keywords: boilers, combustion, resource, nitrogen oxides, energy efficiency

Abstract

The increases service life of gas hot water supply boilers with uniform heat supply along of the depth (width) of the combustion chamber for more than 40 years, by using of slot bottom burners was shown. While reducing nitrogen oxide emissions by using of dual-screens its can significantly increase the heat stress of the furnace, the volume of the furnace chamber and the temperature of the flue gases had left unchanged. The boilers with a capacity of 1–10 MW, with the above technical design solutions of the Gas Institute of the NAS of Ukraine, with a total heat capacity of more than 60 GW, continue to be operated and produce in Ukraine and the CIS countries. Installed boilers relatively nitrogen oxide emissions comply with new EU directive (EU) 2015/2193. The using of gas slot bottom burners can reduce nitrogen oxide emissions by approximately 15 % compared to the basic factory vortex types GMG or GMGB installed on many boilers was shown. A project for the reconstruction of boilers TVG-8 (TVG-8M) and KVG-7.56 with an increase in convective surface area by replacing the factory pipe 28x3 mm with 32x3 mm had developed. Using the improved slot bottom burners in particular equipped with calibrated nozzles for precise dosing of natural gas into the air was envisaged. As a result of a research test of the reconstructed boilers for 3-5 years these technical solutions could increase the energy efficiency of existing TVG and KVG boilers up to the current European level —94–95 at rated heat output was shown. Ref.18, Fig.4, Tab. 5.

Author Biographies

I.Ya. Sigal, The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv

Doctor of Technical Sciences, Professor

A.V. Smikhula, The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv

Candidate of Technical Sciences

E.P. Dombrowska, The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv

Candidate of Technical Sciences

O.V. Marasin, The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv

Candidate of Technical Sciences

References

Buznikov E.F., Sidorov V. [Heat-water supply boilers and their use in power plants and boiler rooms]. Moscow : Energiya, 1965. 240 p. (Rus.)

Sigal I.Ya., Lavrentsov E.M., Kosinov O.I., Dombrovskaya E.P. [Gas-fired heat-water supply industrial boilers]. Kiev : Tekhnika, 1967. 145 p. (Rus.)

Certificate of authorship 173396 USSR, MPK F 24 D. [Gas-fired heat-water supply boiler] I.Ya.Sigal, E.M.Lavrentsov, E.P.Dombrovskaya. 925898/24-6; zajavl. 21.10.1964; Publ. 07.04.1965, Bull. 15. (Rus.)

Certificate of authorship 197915 USSR, МPК F 24 D. [Boiler for liquid heating] I.Ya.Sigal, E.P.Dombrovskaya, E.M.Lavrentsov, D.G.Vekselman, L.Ya. Edelson. 1065481/24-6; zajavl. 24.03.1966; Publ. 09.06.1967, Bull. 13. (Rus.)

Sigal I.Ya., Lavrentsov E.M. [Gas-fired heat-water supply industrial boilers]. Energetika i elektrifikatsiya. 1967. No. 2. pp. 10–12. (Rus.)

Sigal I.Ya. [Protection of ambient air at fuel burning]. Leningrad : Nedra, 1988. 313 p. (Rus.)

Kosinov O.I. [Investigation of the influence of heat transfer intensification on the formation of nitrogen oxides in boiler furnaces]. Avtoref. dis. ... kand. techn. nauk. Kiev, 1975. 27 p. (Rus.)

Smikhula A.V. [Development and research of power bottom slot burners for tower hot water boilers]. Avtoref. dis. ... kand. techn. nauk. Kiev, 2007. 20 p. (Ukr.)

Kamenetsky B.Ya. [Strength of screen pipes of boilers]. Novosti teplosnabzheniya. 2012. No. 5. pp. 33–35. (Rus.)

Directive (EU) 2015/2193 (2015) Of the European parliament and of the council of 25 November 2015 on the limitation of emissions of certain pollutants into the air from medium combustion plants, Official Journal of the European Union, 2015, 28 November, 19 p.

Dudley B. et al. BP Statistical Review of World Energy June 2019, The Editor BP Statistical Review of World Energy, 68th edition, London, 2019. 61 p.

Pat. Utility model UA 51709 UA. MPK F 24 H. [Direct-flow gas-fired heat-water supply boiler]. E.M. Lavrentsov, I.Ya.Sigal, A.V.Smikhula, V.Ya. Skripko, G.P.Kuchin, O.S.Kernazhytska. u201001768; zajavl. 18.02.2010; Publ. 26.07.2010, Bull. 14. (Rus.)

Pat. Utility model UA 52028 UA, MPK F 24 D. [Burner for gas burning]. I.Ya.Sigal, O.I.Sigal, A.V.Smikhula, E.M.Lavrentsov, E.P.Dombrovskaya. u201001705; zajavl. 17.02.2010; Publ. 10.08.2010, Bull. 15. (Rus.)

Lavrentsov E.M., Sigal I.J., Smikhula A.V., Berezanskiy V.V., Ovchar V.V. [Water Boilers of TVG and KVG Types Modernization]. Energotechnologii i Resursosberezhenie. [Energy Technologies and Resource Saving]. 2010. No. 6. pp. 70–76. (Rus.)

Sigal I.Y., Smikhula A.V., Marasin O.V., Lavrentsov E.M. [The increasing duration of operation of boiler houses and heat electro power stations above 12 MW in Ukraine]. Energotechnologii i Resursosberezhenie. [Energy Technologies and Resource Saving]. 2015. No. 3. pp. 46–53. (Rus.)

Sigal I.Ya., Smikhula A.V., Duboshiy O.M., Horbunov O.V., Horbunov А.O. [Reducing the formation of nitrogen oxides during the combustion of natural gas]. Energotechnologii i Resursosberezhenie. [Energy Technologies and Resource Saving]. 2016. No. 4. pp. 44–51. (Rus.)

Sigal I.Ya., Smikhula A.V., Marasin O.V., Lavrentsov E.M., Dombrowska E.P. [Modernization of gas boilers of TPP, CHP and boilers rooms to the EU directive ecological requirements]. Energotechnologii i Resursosberezhenie. [Energy Technologies and Resource Saving]. 2017. No. 4, pp. 61–70. DOI: 10.33070/etars.4.2017.09 (Ukr.)

Smikhula A.V., Sigal I.Ya., Bondarenko B.I., Semeniuk N.I. [Technologies for reduction of harmful emissions to the atmosphere of thermal power plants and boiler-houses of large and medium power of Ukraine] Kiev : FOP Maslakov, 2019. 108 p. (Ukr.)

Published
2019-09-20
How to Cite
Lavrentsov, E., Sigal, I., Smikhula, A., Dombrowska, E., Kernazhytska, O., & Marasin, O. (2019). EXPERIENCE OF DEVELOPMENT, IMPLEMENTATION AND MODERNIZATION OF HOT WATER SUPPLY BOILERS WITH DUAL-SCREENS AND THE SLOT BOTTOM BURNERS. Energy Technologies & Resource Saving, (3), 17-26. https://doi.org/10.33070/etars.3.2019.02

Most read articles by the same author(s)