SERVICE LIFE EXTENTION OF BOILERS OVER 12 MW USED IN INDUSTRY, HOUSES HEATING AND HEAT ELECTROPOWER STATIONS

  • I.Y. Sigal The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv
  • A.V. Smikhula The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv
  • O.V. Marasin The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv
  • E.M. Lavrentsov The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv
Keywords: boilers, combustion, resource, nitrogen oxides, recirculation

Abstract

In Ukraine there is the technical possibility low-cost modernization of existing industrial and heating boilers, which capacity from 12 MW and they achieved the expiration date, with increasing duration of operation for 15–20 years and bringing their technical, economic and environmental performance to the modern world’s level. When the boiler house operates at nominal capacity, and has significant residual duration of operation, it is necessary to include the following activities: the increase of surface heating of boilers to achieve modern efficiency; the application of various methods of reducing emissions of NOx. When boiler operating in less than 2/3 of peak power of the nominal capacity should: the decrease value of the nominal capacity of boilers to economically expedient in view of the exhaust gases temperature; the creation of exhaust gases recirculation in boilers using existing draught-blowing equipment. In both cases it is necessary replace the burner on improved one with low NOx emissions.Bibl. 16, Fig. 10.

Author Biographies

I.Y. Sigal, The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv

Doctor of Technical Sciences, Professor

A.V. Smikhula, The Gas Institute of the National Academy of Sciences of Ukraine, Kyiv

Candidate of Technical Sciences

References

Enerhetychna stratehiya Ukrayiny na period do 2030 r. / Cabinet of Ministers of Ukraine — Law of Ukraine, [El. resource]. — Mode of access: — http://zakon4.rada.gov.ua/laws/file/text/24/ f417479n5.zip. (Ukr.)

Sigal I.Ya., Dombrowska E.P., Bilodid V.D., Lavrentsov E.N., Smikhula A.V., Shyshowski A.O., Kolchev V.A. Status analysis of boilers management in Ukraine for modernization, resort prolong and substitution of boilers by small and middle capacity Ecotechnologii i resursosberezhenie [Ecotechnology and Resource Saving], 2003, (6), pp. 76–79. (Ukr.)

Sigal I.Ya., Dombrowska E.P, Smikhula À.V. To a question on modernization of a boiler economy of Ukraine Ecotechnologii i resursosberezhenie [Ecotechnology and Resource Saving], 2004, (3), pp. 66–69. (Rus.)

Pro vstanovlennya rozdribnykh tsin na pryrodnyy haz, shcho vykorystovuyetsya dlya potreb naselennya / The National Commission for State Regulation in Energy and utilities, Ukraine — Law of Ukraine, 05.03.2015, ¹ 583. — http://www.nerc. gov.ua/ index.php?id=14329 (Ukr.)

Sigal I.Ya., Gurevich N.A. K voprosu o dline fakela vihrevyh gazovyh gorelok / Teoriya i praktika szhiganiya gaza, Leningrad : Nedra, 1968, 4, pp. 177– 185. (Rus.)

Sigal I.Ya. Protection of ambient air at fuel burning. Leningrad : Nedra, 1988, 313 p. (Rus.) 7. Sigal I.Yà., Duboshiy A.N., Smikhula A.V. Reduction of emissions of nitrogen oxides by power boilers. Energetika i elektrifikaciya, 2005, (1), pp. 31–35. (Rus.)

Sigal I.Ya., Duboshiy A.N., Sigal O.I., Smikhula A.V. The efficiency increase of smoked gases recirculation influence on nitrogen oxides emission from power plant boilers reduction. Energotechnologii i resursosberezhenie [Energy Technologies and Resource Saving],2010, (1), pp. 48–52. (Rus.)

Sigal I.Ya., Kopeyka I.G., Ovchar I.G. Influence of intermediate emitters heat transfer and the kinetics of formation of nitrogen oxides in boiler furnaces. Encotechnologii i resursosberezhenie [Ecotechnology and Resource Saving], 1994, (5–6), pp. 56–61. (Rus.)

BP Statistical Review of World Energy, Energy Academy and Centre for Economic Reform and Transformation, Heriot-Watt University, June 2014, 50 ð. [El. resource]. — Mode of access. — http://www.bp.com/content/dam/bp/pdf/Energyeconomics/statistical-review-2015 /bp-statis¬ticalreview-of-world-energy-2015-full-report.pdf.

Leluk O.V. Analiz osoblivostey ukrainskogo rinku vidobutku ta spozhivannya prirodnogo gazu. Businessinform, 2013, (11), pp. 170–179. (Ukr.)

Sigal I.Ya., Nignik S.S. Zmenshennya utvorennya oksidiv azotu retsirkulyatsíêyu produktiv zgoryannya,Tsukor Ukrainy,1994, (3), pp. 14–16. (Ukr.)

Directive 2010/75/EU of the European Parliament and of the Council of 24 November 2010 on industrial emissions (integrated pollution prevention and control), 119 p. [El. resource]. — Mode of access. — http://eur-lex.europa.eu/legal-content/EN/ TXT/ ?uri=CELEX: 32010L0075

Association Agreement between the European Union and the European Atomic Energy Community and their Member States, of the one part, and Ukraine, of the other part, Law of Ukraine, 27.06.2014, 277 p. [El. resource]. — Mode of access. http:// www. consilium.europa.eu/en/docu¬ments-publications/ agreements-conventions/agreement/?aid= 2014045

Copyright certificate the USSR 1206558, IPC F 23 D 14/00. Burner device, G.F.Naidenov, A.D. Gorba- nenko, Yu.P.Eniakin, A.S.Kusch, I.Ya.Sigal. — Publ. 23.01.86. (Rus.)

Pat. for utility model, Ukraine UA 47928, IPC F 23 D 14/00. Burner for natural gas, I.Ya.Sigal, A.I.Sigal, A.V.Smikhula. — Publ. 25.02.2010. (Ukr.).

Published
2015-06-20
How to Cite
Sigal, I., Smikhula, A., Marasin, O., & Lavrentsov, E. (2015). SERVICE LIFE EXTENTION OF BOILERS OVER 12 MW USED IN INDUSTRY, HOUSES HEATING AND HEAT ELECTROPOWER STATIONS. Energy Technologies & Resource Saving, (3), 46-55. https://doi.org/10.33070/etars.3.2015.05
Section
Environment protection

Most read articles by the same author(s)