MODELING OF GROWTH AND EVALUATION ANTICORROSIVE PROPERTIES OF SCALE

  • N.A. Bilousova National Technical University of Ukraine «Igor Sikorsky Kyiv Polytechnic Institute», Kyiv
  • Yu.S. Herasymenko National Technical University of Ukraine «Igor Sikorsky Kyiv Polytechnic Institute», Kyiv
  • R.M. Red’ko National Technical University of Ukraine «Igor Sikorsky Kyiv Polytechnic Institute», Kyiv
  • I.Yu. Vichkan National Technical University of Ukraine «Igor Sikorsky Kyiv Polytechnic Institute», Kyiv
Keywords: scale, scale growth rate, antiscalant, corrosion rate

Abstract

The work concerns investigation of scale formation in the mode of boiler water with high hardness and definition of efficiency anticorrosive antiscalant action. The experimental setup and method of determining the specific rate of scale formation and steel corrosion rates under controlled water supply, which provides a constant concentration of hardness salts, and a maximum rate of scale deposition, as well as the constancy of the concentration of antiscalant were developed. The functional dependencies of the specific scale mass gains in time for the investigated antiscalant HEDP, LWCh-1.1 (based on organophosphonates) and SeaQuest (based on polyphosphate) are linear. The structure and anticorrosive properties of the formed scale depend not only on the nature and concentration of antiscalant, but also from the fresh water replenishment rate. In comparative tests with the same concentrations of reactants it found that the best inhibitory and anti-scale properties have HEDP in the water with hardness of 20.2 mM/dm3. The developed technique and produced dependencies allow predicting antiscale and anticorrosive action of reagents for boiler of small power plants that operate without water treatment during the heating season. Bibl. 11, Fig. 4.

Downloads

Download data is not yet available.

Author Biographies

N.A. Bilousova, National Technical University of Ukraine «Igor Sikorsky Kyiv Polytechnic Institute», Kyiv

Candidate of Technical Sciences

Yu.S. Herasymenko, National Technical University of Ukraine «Igor Sikorsky Kyiv Polytechnic Institute», Kyiv

Doctor of Technical Sciences, Professor

References

DNAOP 0.00.-1.26-96, [Terms of design and safe operation of steam boilers with steam pressure not exceeding 0.07 MPa (0.7 kgf/cm2), boilers and water heaters heat water with a temperature no higher than 115 C], Kiev : State regulation of labor protection, 1996, 128 p. (Ukr.)

Balaban-Irmenin Ju.V., Suslov P.S. [Features of antiscale in heating systems], Proceedings of the IV Conference «Modern water treatment technology and corrosion protection of equipment and scale formation». — [Electron resource]. — http://www.travers.su/upload/iblock/ b14/b14caa976c3907580eb8aa6a5b179ddf.pdf (Rus.)

Rudakova G.Ja., Samsonova N.K., Larchenko V.E. [Some aspects of the practice and use of complexions for water treatment], Jenergosberezhenie i vodopodgotovka, 2007, (2), pp. 32–33. (Rus.)

Driker B.N., Sikorskij I.P., Cirul’nikova N.V. [Explore the use of zinc complexonates IOMC for the inhibition of structural steels corrosion], Jenergosberezhenie i vodopodgotovka, 2006 (2), pp. 7–9. (Rus.)

Nesterenko S.V. [Feed water treatment technology to prevent corrosion and scaling processes on heat transfer surfaces], Kommunal’noe hozjajstvo gorodov, 2008, Iss. 84, pp.190–194. (Rus.)

Pager S., Gerasimenko Ju. [Inhibiting effect of scale formed in the ultrasonic field on heat transfer surfaces], Fiziko-himichna mehanika materialiv. Problemi korozii i protikorozijnogo zahistu materialiv, L’viv, 2012, 1 (9), pp. 272–278. (Ukr.)

DSTU 3895–99. (GOST 9.514-99). [Corrosion inhibitors of metals for water systems. Electrochemical method for determining the protective ability]. (Ukr.)

Gerasimenko Ju.S., Nechaj M.V., Belousova N.A., Shlokova E.A. [Estimation of the accuracy of measurements of corrosion rate by the method of polarization resistance], Fiz.-him. mehanika materialov, 1996, 31 (3), pp. 302–306. (Rus.)

[Encyclopedia of heating. Deposits and abrasion]. — [Electron resource]. — http://www.rosteplo. ru/w/ (Rus.)

Potapov S.A. [Complexions water-chemical mode of heat supply system. Problems and solutions], Materials of the conference «Modern technologies of water treatment and protect equipment from corrosion», Moscow, June 2003, IREA, pp. 20–28. (Rus.)

Gerasimenko Ju., Bilousova N., Red’ko R. [Scale, its anticorrosive properties and regulation], 13th International Conference «Corrosion 2016», Lvov, Ukraine, 14–15 June 2016, Lvov, 2016. (Ukr.)

Published
2016-06-20
How to Cite
Bilousova, N., Herasymenko, Y., Red’ko, R., & Vichkan, I. (2016). MODELING OF GROWTH AND EVALUATION ANTICORROSIVE PROPERTIES OF SCALE. Energy Technologies & Resource Saving, (2), 37-43. Retrieved from https://etars-journal.org/index.php/journal/article/view/119
Section
Raw material processing and resource saving